Study on Stability and Reliability of Wind Turbine Transmission Chain under the Coupling of Multiple Physical Fields
DOI:
https://doi.org/10.54097/aqs7xq17Keywords:
Stability, Reliability, Wind Turbine, Transmission Chain, Multiple Physical FieldsAbstract
The transmission chain of wind turbine has been subjected to the coupling effect of mechanical, electromagnetic, thermal and fluid fields for a long time in complex service environment. It is difficult to reveal its nonlinear failure mechanism by traditional single field analysis method, which restricts the improvement of system stability and reliability. In this paper, the stability and reliability of wind turbine transmission chain under the coupling of multiple physical fields are systematically studied, and a mechanical-electromagnetic-thermal-fluid four-field coupling dynamic model is constructed to quantify the influence law of coupling effect on the dynamic response of transmission chain. A stability evaluation framework based on digital twinning is proposed, which integrates high fidelity simulation, real-time monitoring and machine learning to realize dynamic mapping of multi-field States and early fault warning. Further facing the whole life cycle, the collaborative optimization of structural topology optimization, electromagnetic parameter matching and intelligent lubrication regulation is carried out, which significantly improves the robustness of transmission chain under variable load conditions. The experimental results show that the vibration amplitude of the optimized system is reduced by 33.3%, the torque fluctuation coefficient is reduced by 38.8%, and the maximum temperature rise is reduced by 18.5%. The model prediction is highly consistent with the measured data, which verifies the effectiveness and engineering applicability of the proposed method. The research provides theoretical support and technical path for multi-field coupling analysis and reliability design of wind turbine transmission chain.
Downloads
References
[1] Gao X, Chen L ,Zhang Z .Cost driving wind turbine main bearing system concept design with modularization and equivalent simplification method[J] .Journal of Mechanical Science and Technology,2025,39(9):1-10.
[2] Hemati A ,Shooshtari A .The Planetary Gearbox Vibration Root Cause Failure Analysis Using Velocity Spectra and Time Signal Analysis[J] .Journal of Failure Analysis and Prevention, 2025, 25(1):1-16.
[3] ShaoZ ,LiuZ ,ZhangY , et al.Fatigue Life Prediction and Reliability Assessment of CFRP Adhesively Bonded Joints in Offshore Wind Turbine Blade Applications: A Physics‐Informed Data‐Driven Approach[J] .Quality and Reliability Engineering International,2024,41(3):943-956.
[4] Nie Y ,Lu H ,Chen X , et al.Interpreting vibration characteristics of planetary gearboxes for condition monitoring based on a novel transfer path effect model[J] .Nonlinear Dynamics,2024,113(9):1-21.
[5] PanditR ,SantosM ,García SE J .Comparative analysis of novel data‐driven techniques for remaining useful life estimation of wind turbine high‐speed shaft bearings[J] .Energy Science & Engineering,2024,12(10):4613-4623.
[6] JungW S ,KangD ,PalanimuthuK , et al.Design of 20 MW direct‐drive permanent magnet synchronous generators for wind turbines based on constrained many‐objective optimization [J] .Wind Energy,2024,27(9):847-872.
[7] Zongyao L ,Shixiang M ,Lin L , et al.Research on vibration spectral structures of planetary gearboxes based on a universal equation of phenomenological modeling[J] .Nonlinear Dynamics,2024,112(10):8129-8151.
[8] Tchoumtcha B D ,Dagang S T C ,Kenne G .Synergetic control for stand-alone permanent magnet synchronous generator driven by variable wind turbine[J] .International Journal of Dynamics and Control,2024,12(8):2888-2902.
[9] Mouna Z ,Intissar M ,Adel K .Sliding Mode Control for Wind Turbine Emulator based on Advanced Space Vector Modulation Technique for Two-Phase Induction Motor Drive [J]. IETE Journal of Research,2024,70(2):1800-1813.
[10] Lam P Y ,Simani S .Data–Driven Adaptive Fault–Tolerant Control for Floating Offshore Wind Turbines[J] .IFAC PapersOnLine, 2024,58(4):306-311.
[11] Shehata G E .Improved Power Control of DFIGs Driven by Wind Turbine under Unbalanced Grid Voltage[J] .Journal of Electrical Engineering & Technology,2024,19(1):325-340.
[12] ElHasan S T .Air‐cored axial flux permanent magnet generator for direct driven micro wind turbines[J] .IET Renewable Power Generation,2023,17(15):3687-3700.
[13] Pandit R ,Xie W .Data‐driven models for predicting remaining useful life of high‐speed shaft bearings in wind turbines using vibration signal analysis and sparrow search algorithm [J]. Energy Science & Engineering,2023,11 (12): 4557-4569.
[14] Engin H ,Yusuf Ç .Experimental Investigation of Magnet Grouping Technique in Reduction of Cogging Torque and Total Harmonic Distortions in the Axial Flux PM Generator for Direct Drive Wind Turbine[J] .Electric Power Components and Systems,2023,51(18):2181-2192.
[15] Fang W .Inertia control method of direct drive permanent magnet wind turbine under high wind power permeability [J]. Journal of Computational Methods in Sciences and Engineering, 2023,23(4):2225-2235.
[16] Jing Y ,Zeming L ,Rongxi W , et al.A novel self-learning framework for fault identification of wind turbine drive bearings[J]. Proceedings of the Institution of Mechanical Engineers, 2023, 237(7):1296-1312.
[17] Han T. Automatic identification of wind turbine operation status based on data mining[J] .Computer Informatization and Mechanical System,2023,6(5):63-67.
Downloads
Published
Issue
Section
License
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
